Transverse and longitude timing
belt service with full parts kit including timing belt, water pump with metal
impellar, thermostat, thermostat housing, serpentine belt, tensioner roller,
tensioner damper, chains where applicable, and coolant. All OEM manufacturer
parts. (1.8T timing belt service comes with the R.A.I. Motorsport Kevlar 1.8T Timing Belt).
$600 - 2.0L 8V
$800 - 1.8T
$900 - 2.8L, 2.7L,V6
$1000 - 3.0L V6, 3.2L and 2.8L VR6
Hydraulic Flush
VW: $125
This is a complete flush of your old hydraulic fluid. We replace it with either
Pentosin Racing, ATE Super Blue, or Motul.
Manual Transmission Flush
VW: $125
This is a complete flush of your Manual Transmission Fluid. We replace the
fluid with Red Line MT-90, or Motul.
DSG Transmission Service
$215
This is the DSG service that should be done every 40K. Filter and fluid are
replaced with genuine parts.
Automatic Transmission Service
VW: $175
This is the maintenance flush for the transmission. Parts include filter and
fluid, all are genuine OEM.
Haldex Service
$130
This is the Haldex service due every 20k for your Haldex equipped AWD vehicle.
Parts include genuine OEM filter and fluid.
*Newest
Services*
FSI/TSI Intake Valve Carbon Build Up Prevention/Service
$150
This service is intended to prevent
the buildup of carbon deposits on the intake valves of your FSI/TSI engine.
This service is not intended for removing large amounts of previously deposited
carbon buildup on the intake valves, but rather for preventing this large buildup
from ever occurring. Our R&D department has thoroughly and carefully tested
this procedure and it has proven its efficiency. If you have not yet had your
FSI/TSI intake valves cleaned, we highly recommend an initial cleaning with
annual treatments every 15K. With this service you will receive before and
after photos/video from our borescope to see how the service is actually
working.
For those of you who are unfamiliar with the carbon build up problem in the
FSI/TSI engine, the concept is simple. FSI technology works by relocating the
fuel injectors from the intake manifold, and positioning them to spray directly
into the combustion chamber. In turn, the intake valves are no longer kept
clean by the spray of your fuel injectors. This results in a buildup of carbon,
on the intake valves, at a very rapid rate. During our prevention service testing
we found that after hand cleaning valves that had 42k on them, there was an
average of 7 wheel horsepower increase throughout the power band, as well as
improved driveability and fuel mileage. We treated several of our test cars and
the results have proved that this prevention service works wonders.
10% OFF Factory Scheduled Maintenance Service Intervals
No matter what kind of vehicle you
own, there are mileage specific maintenance services required by the factory to
preserve the life of your vehicle. These services include inspections,
cleaning/lubricating, as well as wear part replacement. We perform a full
inspection and complete all services according to factory guidelines, in
addition to exceeding the factory requirements. Owner's manual is always
updated with latest services completed.
Cooling System Flush
$100
This service exchanges your old
coolant/antifreeze with new OEM fluid, and also includes a new reservoir
bottle. The cooling system is also pressure tested to ensure optimal operation.
Redline water wetter is also added to maximize cooling system performance.
Dyno Services
At RAI Motorsport we own a Mustang
Dynamometer AWD-500 series. We purchased this machine after spending countless
months researching and comparing the differences between all dynamometers on
the market today. And after speaking with several "mobile tuners", it became
apparent that the Mustang Dynamometer is preferred over all others. The
strength of the MD-AWD-500 Series is in its ability to test both axles of the
vehicle under the same imposed load; while at the same time synchronizing front
and rear wheel speed. With a wheelbase range of 88" to 118" and a
maximum track width of 80", the MD-AWD-500 Series has the capability of
testing any AWD or 2WD car on the road today.
2WD Testing
For $75 you will receive 3 baseline runs of your 2WD vehicle with
O2 readings.
AWD Testing
For $110 you will receive 3 baseline runs of your AWD vehicle
with O2 readings.
